Thread: 2004 Grand Prix Cuts Out While Driving

Hello Everyone!

Got another issue with my 2004 Grand Prix GT2......300k Highway Miles runs like a dream, until recently.

I will be driving down the road and it could take anywhere between 5 minutes and 10 minutes but the car will just shut off. The first time it wanted to shut off I kind of prevented it from shutting off by giving it a little gas but now It wont stall or "choke", it just seems like power is gone. No certain speed at all, just driving normally and it will just shut off. I will restart it and go on my way but will shut off after a few minutes, its a repetitive cycle. Can anyone help me on this??? It has happen 4 times already twice tonight and twice yesterday, its pretty dangerous especially when not wanted it to happen at high speeds.

I have looked into it on different forums and I have read it could be : Fuel Pump/ Crankshaft Position Sensor/ MAF Sensor/ Dirty Throttle Body.....the list goes on and on.

Recent Work that I have done most likely have nothing to do with this problem : Water Pump Replacement/ New Battery/ Coolant Flush and Fill and a new thermostat. When doing the water pump I did remove the big fuse box that is under the hood to get out of my way, but made sure I put it back together when done. All the work was done 3 weeks ago, but this problem just happened.

If someone can help me eliminate some of the listed "Fixes" without buying the parts just yet I would greatly be thankful!

Thanks Guys

Paul

Tune Up was done about 800 miles ago...I tune it up every 50k miles........

Will do, first thing in the morning I will take off the TB spray it down clean it nice, I will also clean the MAF...any special things I must to when cleaning MAF? Recommend anything?

Will follow up tomorrow thanks

Originally Posted by KeithGTP03

Does your tach quit working right before it stalls? Sounds like the infamous Crank position sensor. And it rarely throws a SES light or code. Mine finally did after a month of doing that crap. That was back in 2001, before all these forums, so it was fun to track down the problem.

Keith, thanks for the response!...I will drive it around the subdivision tomorrow and play close attention to the tach, if the tach drops down to zero before the stall, should i just go ahead and replace the Crack Pos Sensor?

Bad or loose battery connection?

One of the first things I checked.......

When it runs does it run good like no chugging hesitation ect?

Runs perfect until it cuts out......the first time it hesitated, but now its just like someone turned off the ignition....just dies.

Bro from the way it sounds it most likely is the CPS ... have your battery checked also if its old especially ...

I just watched a video on replacing the CPS......I don't even have the tool to pull of the balancer, this is not good HA!

Easy just rent it from orielly or auto zone... its not that bad. Take off tire and splash shield.

Will do, thanks for all your help guys.

I will update in a day or two when have it figured it out

I did the same but it was to replace my balance. Its not bad

Drove the dang car around for an hour today....couldn't get it to shut off.

I have my TB and MAF sensor cleaner ready. I also have my fuel pump pressure gauge ready and went out and purchased a CSP sensor from AutoZone (Duralast) on hand.....They also let me borrow the puller.

I will keep all the Pontiac guys out there updated as soon as I figure it out....